A Study of MACI in Patients Aged 17 to 65 Years With Symptomatic Chondral or Osteochondral Defects of the Ankle

Official title

A Prospective, Open-label, Randomized, Concurrent Active-controlled, Longitudinal, Multicenter, Phase 3 Clinical Study of the Safety and Efficacy of MACI in Patients With Symptomatic Chondral or Osteochondral Lesions of the Talus (MASCOT)

Overview

The objective of this study is to demonstrate the superiority of MACI (autologous cultured chondrocytes on porcine collagen membrane) versus Bone Marrow Stimulation in the treatment of patients aged 17 to 65 years with symptomatic articular chondral or osteochondral defects of the talus.

Detailed description

This is a 2-year prospective, multicenter, two-arm, parallel-group open-label clinical trial in which a total of 309 subjects, ages 17 to 65, will be randomized 2:1 to receive a 1-time treatment in the ankle with MACI or arthroscopic BMS.

After meeting screening criteria at the initial visit (Visit 1), all participants will have an index ankle arthroscopy within 8 weeks to further assess clinical trial eligibility. During the index ankle arthroscopy (Visit 2), participants will be further evaluated against entry criteria. Cartilage lesion size will be measured before randomization and any cartilage repair procedure. Only participants with at least 1 lesion ≥ 1.2 cm² on the talus will be eligible for inclusion in the clinical trial.

All participants who meet the eligibility criteria and are considered suitable for treatment in the clinical trial by their surgeon will have a cartilage biopsy taken prior to randomization to study treatment. Eligible participants will be randomized 2:1 to receive either MACI or Bone Marrow Stimulation. Participants randomized to Bone Marrow Stimulation will undergo the procedure during the Visit 2 ankle arthroscopy. Subjects will be asked to follow a recommended postoperative rehabilitation program.

All biopsied tissue will be sent to the Vericel Corporation manufacturing facility in Massachusetts, where the sample will be processed to isolate the autologous chondrocytes, undergo cell culture expansion through at least the primary phase, and cryopreservation. Additional expansion of the cells will occur after the MACI implantation surgery has been scheduled.

Participants assigned to the MACI treatment arm will return within 5 to 12 weeks of the Visit 2 ankle arthroscopy to undergo MACI implantation procedure via arthrotomy (Visit 3). Participants will be asked to follow a recommended postoperative rehabilitation program.

All subjects will be assessed post-study treatment at Weeks 6 and 12 for safety and at Weeks 24, 36, 52, 78, and 104 for safety and efficacy. Rehabilitation status will be monitored at all post-treatment visits through Week 52.

Interventions

• Biological autologous cultured chondrocytes on porcine collagen membrane
  An autologous cellularized scaffold combination product being studied for the repair of symptomatic, single or multiple full-thickness cartilage defects of the talus with or without bone involvement in adults.
• Procedure Bone Marrow Stimulation
  A surgical awl or microdrill will be used to make multiple holes in the exposed base of the lesion. The microfracture procedure should result in holes that are approximately 3 to 4 mm apart. When fat droplets can be seen coming from the marrow cavity, the appropriate depth (approximately 2 to 4 mm) has been reached. The released marrow elements (including mesenchymal stem cells, growth factors, and other healing proteins) form a surgically induced clot that provides an enriched environment for

Primary outcome measures

• Change from Baseline to Week 104 in the FAOS Pain and Function (SRA) subscale scores [Time frame: Baseline to Week 104]

Secondary outcome measures (2)

• Percentage of participants who respond to study treatment after 2 years, i.e., participants who have ≥ 10-point improvement on both the FAOS Pain and Function (SRA) subscale scores from Baseline to Week 104. [Time frame: Baseline to Week 104]
• Change from Baseline to Week 104 in the remaining FAOS subscales scores [Symptoms, Function (Daily Living) and Quality of Life] [Time frame: Baseline to Week 104]

Eligibility criteria

Inclusion criteria

• Age 17 to 65 at the time of planned randomization visit (Visit 2).
• One or more symptomatic chondral or osteochondral lesion/s as defined by FAOS Pain score ≤ 50 and FAOS Function (SRA) score ≤ 50.
• International Cartilage Repair Society (ICRS) Score Grade 3 or 4 chondral or osteochondral lesion/s located on the talus with or without cysts, including shoulder lesions (lesions on the talar neck), and amenable to treatment with the surgical procedure specified at randomization.
• At least 1 lesion ≥ 1.2 cm².
• Written informed consent and assent (as applicable) per Institutional Review Board (IRB) requirements.
• Participant will refrain from using Non-steroidal Anti-inflammatory Drugs (NSAIDS) for 12 weeks post-study treatment. (Post-surgical use of low-dose aspirin for clot prevention is acceptable).
• Participant will restrict pain medication to over-the-counter analgesics (NSAIDs or acetaminophen/paracetamol) after 12 weeks post-study treatment.
• Participant must have Hematocrit ≥30.0%; White Blood Cell count ≤14,000 cells/μL; Platelet Count ≥50,000 platelets/μL; Creatinine ≤2.0 mg/dL; and International Normalized Ratio (INR) ≤1.6.

Exclusion criteria

• Lesions with an underlying bony defect depth of > 5 mm.
• Any surgery on the target joint within 24 weeks prior to Visit 1 (not including diagnostic ankle arthroscopy).
• Previous investigational drug, biologic or device use within 12 weeks prior to Visit.
• Avascular necrosis of the target ankle.
• Symptomatic musculoskeletal conditions in the lower limbs that could impede measurement of efficacy for the target ankle joint.
• Participant with "kissing lesions" (bipolar lesions, involving both the tibia and talus), or with bilateral lesions in both ankles.
• Participant with lesions that require an osteotomy procedure to allow for MACI implantation as determined at the time of ankle arthroscopy (Visit 2).
• Concomitant systemic inflammatory diseases or other conditions that affect the joints (e.g., rheumatoid arthritis, metabolic bone disease, psoriasis, symptomatic chondrocalcinosis).
• History of advanced or severe osteoarthritis of the ankle as determined by prior surgical history confirming no joint space (i.e., "bone on bone") or radiographic evidence of Modified Kellgren-Lawrence Grade 4 arthritis (i.e., osteophytes on lateral and medial malleoli and at the tibiotalar joint margins, narrowing of the joint space width > 50%, and tibiotalar sclerosis), Van Dijk Grade III (i.e., total or subtotal destruction of the joint space) or the equivalent.
• Known history of septic arthritis in the target ankle joint within 1 year prior to Visit 1.
• Current malignancy or treatment for malignancy within the past 5 years prior to Visit 1, excluding non-melanoma skin cancer.
• Known history of hypersensitivity to gentamicin, other aminoglycosides, or products of porcine or bovine origin.
• Females who are pregnant or lactating.
• Patients who, in the opinion of the Investigator, have significant medical or psychosocial problems that warrant exclusion. Examples of significant problems included but are not limited to:

• Any condition that has potential for negatively impacting intra- or postoperative course (e.g., uncontrolled diabetes, heavy smoking). - Uncontrolled diabetes is defined as hemoglobin A1c (HbA1c) ≥8.0% and/or fasting plasma glucose >250 mg/dL (13.9 mmol/L) within the last 90 days prior to Screening Visit 1 - Heavy smoking is defined as current smoker with use of ≥20 cigarettes per day (≥1 pack/day) at the time of Screening Visit 1.
• Conditions that limit compliance with rehabilitation program.
• Any condition that has potential for significantly limiting participant's ability to assess postoperative ankle function.
• Any condition, psychiatric or otherwise, that would preclude informed consent/assent, consistent follow-up, or compliance with any aspect of the clinical trial.
• Participant is currently abusing drugs or alcohol or, in the opinion of the Investigator, at high risk for poor compliance.
• Any abnormal screening blood work that the Investigator deems clinically significant in addition to the parameters delineated in Inclusion Criterion #8.
• Injection of hyaluronic acid (HA), platelet-rich plasma (PRP), and/or corticosteroids in the target ankle within 90 days prior to Visit 1.

Criteria are shown verbatim from the registry (in English). Final eligibility is always assessed by the study center.

Healthy volunteers: No

Study design

Allocation

Randomized

Model

Parallel assignment

Masking

Open label

Primary purpose

Treatment

Study locations

United States · 7 centers

• UC Davis Foot and Ankle Clinic — Sacramento
• MedStar Georgetown University Hospital — Washington D.C.
• Elevate Clinical Research Wichita — Wichita
• Duke Orthopaedic Surgery — Durham
• Elevate Clinical Research — Houston
• Rodaro, LLC — San Antonio
• University of Virginia — Charlottesville

Identifiers

NCT: NCT06915233 · 55-2410-01

Primary sources (government registries)

• ClinicalTrials.gov (US NIH)

View this study on ClinicalTrials.gov ↗